York Sunline 2000 Provozní pokyny

1GBOperating InstructionsSunline 2000packaged air conditionerswith gas heatingmodels D3IG 180, 240 and 300 (Euro 50 Hz)TMCGM-97/013ISO 14001ER-028/1/9

10GB- Fig. 8 -GLP/propane gas units, tanks and pipesAll units with gas heating are supplied factory equipped foroperation with natural gas only. The u

11GBThermostatThe ambient thermostat should be located on an inner wall, atabout 1420 mm. above floor level, where it will not be ex-posed to air flow

12GB- Fig. 9 -Unit wiring diagram - 180(01)73(02) (03) (04) (05) (06) (07)6811121213 14910PE166M8360X3/...400V, 3 ~, 50 Hz, N,P3303231304 336PGS32305R

13GB- Fig. 9 -Unit wiring diagram - 240(01)73(02) (03) (04) (05) (06) (07)6811121213 14910PE166M8400V, 3 ~, 50 Hz, N,P3303231304 336PGS32305S3LS1E182S

14GB- Fig. 9 -Unit wiring diagram - 180 and 240I-2079-3a (3 of 4)D3IG180N32050D3IG240N32050IGNITION 2SUMP ELECTRICHEATERS 1 AND 2SUMP ELECTRICHEATERS

15GB- Fig. 9 -Unit wiring diagram - 180 and 2401TDRF5A1RELAYBOARDTD1TD2P9PECBNL1 L2L3Q1M1 M2HHP6TLA3M8GV2GV1OR87654132AB24TR131NTRK2-2K2-2K1-1K1-2+RSR

16GBUnit wiring diagram - 300I-2080-1a (1 of 4)D3IG300N32050(01)3(02) (03) (04) (05) (06) (07)12PE400V, 3 ~, 50 Hz, N,E1L1 L2 L3123546(31)E2X/...KM1NM

17GBUnit wiring diagram - 30035076811121314910166M812P4S4362360X3/...357P3303231304 336PGS32305AS13S3LS1314E184P5316 3092S5P5312P3S311P5S51754RW1(25)S

18GBUnit wiring diagram - 300247282286PHP2PLP2FS21P11S11225PHP1226PLP1FS12393238228S11P11220255RY2(40)357027042037252043S9F3P9RY1(39)356S9P9279TLA3 34

19GBUnit wiring diagram - 300TLA13TDRI-2080-4a (4 de 4)D3IG300N32050A1RELAYBOARDTD1TD2P9P4CBCONTROL PANELP11P7M1 M2HHP6KM4KM1 KM2KM3KM5X1RY1 RY2 RY3 R

2GB

20GB- Fig. 10 -Optional economiser rain-hood/motor-drivendamperThe instructions for the optional economiser rain-hood/motor-driven damper are on the a

21GBCentrifugal fanFan motorTubing depthFins per inchFront surfaceDia. propellerFan motorNominal air flowTubing depthFins per inchFront surfaceTandemS

22GB- Fig. 11 -Front1BackLeft side (access to filter)Right side (outdoor coil)Beneath unit2Over unit3915610 (without economiser)1 245 (with economise

23GB180 400/3/50 16.6 / 9.6 146 / 66 1.5 2.9 4 8.9 40.9 50 10240 400/3/50 2 x 16.6 146 1.5

24GBFanspeedRPM8458859259601 0001 040E.S.P.(Pa)173208245281323369(kW)2.22.32.42.62.72.9E.S.P.(Pa)138172208242283327(kW)2.62.82.93.13.23.4E.S.P.(Pa)831

25GB180 845-1 040 4 28 188 25 1 790 BX69 1240 765-905 5.5 28 236 25 2 040 BX79 1300 980/1 170 7.5 38 235 35 2 123 BX82 2180 1 030-1 240 4 28 188 25 1

26GBOperationCooling systemThe cooling system is a complete factory-mounted assemblythat uses an air-cooled condenser. The system is deliveredloaded w

27GB- Fig. 12 -Low temperature operation: If the outdoor temperature isabove 21º C (70º F), Low Temperature Thermostat TLA isclosed, and Contact KM5 o

28GB- Fig. 13 -control IC2 is locked out.NOTE:Since IC2 is controlled by IC1, any limiting device or failure that maylock out IC1, also disactivates o

29GB- Fig. 14 -of the heat exchanger is 1 mbar (2.5" each).9. Make sure all wiring connections of the gas chamber arecorrect.Start upOperating in

3GB(Mod. D*IG300) - With application of downwarddischarge 25- Table 8 - Static resistance 25- Table 9 - Fan motor and drive specifications 25Operation

30GBFan operating range (RPM)6 845 1 030 765 895 1 010 1 0805 885 1 070 795 925 1 064 1 1304 925 1 115 820 955 1 118 1 1803 960 1 155 850 990 1 172 1

31GB- Fig. 16 -After about 20 minutes of operation, determine the tempera-ture increase in the boiler. Take a reading of both the returnand hot air in

32GB- Fig. 18 -- Fig. 19 -MaintenanceNormal maintenanceCAUTION:Before carrying out any of the following operations, disconnect allelectric power suppl

33GB- Fig. 20 -Trouble shootingGeneral informationBefore trouble shooting in depth, first make sure the thermo-stat is calling for Cool or Heat, and t

34GB2 activated, but contacts K5-2 of relay board are open.Replace the relay board.SEC. 5: No heating, presence of impulse air; ignition con-trol lock

35GBSet point Enthalpy Signal Action"A" Low Y1 The dampers modulate"A" Low Y2 Contact KM1 is operative"D" High Y1 Contac

36GBD3IG 180, 240 & 300TYPE:EC STANDARDS APPLIED:DECLARATION OF COMPLIANCE ON MACHINERYMANUFACTURER:CLIMA ROCA YORK, S.L.ADDRESSE:This machine com

4GB

5GBD 3 IG 180 N 320 50Product identification:IG = International cooling with gas heatingNominal cooling capacity:180 = 52.7 kW (180 MBH)240 = 70.3 kW

6GBThis symbol indicates an electrical dan-ger or risk.Attention: The unit is equipped with remotecontrol and can run automatically. Two min-utes prio

7GBApprox. load at each supporting point (kg)Increment per accessoryD3IGunitsizeBasicunitwithoutacces.Motor-drivendamper or econ.ExtractionfanBarometr

8GBFRONT VIEW- Fig. 3 -- Fig. 4 -Absorbedpower(Nett) kW(Mbh)Givenpower kW(Mbh)ModelsGas consump.*m3/h (cfm)85 / 29076 / 260 8.5 / 302 17 / 30 33 / 60M

9GB- Fig. 5 -MODEL DIG 180 - 240 - 300FEMALE GAS CONNECTION 1"CONNECTING TUBING- Fig. 6 -Gas pipesThe correct sizing of the gas pipes depends upo